TM 11-5820-890-30-4
Section IV. MAINTENANCE PROCEDURES FOR AM-7239/VRC
Subject
General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Operational Check
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Repair Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . .
Removal and Installation of 5A3TB2 Shorting Bar . . . . . . . . . . . . . . . . .
Replacement of
Replacement of
Replacement of
Replacement of
Replacement of
Replacement of
Replacement of
Replacement of
Replacement of
Replacement of
Replacement of
Replacement of
Replacement of
Replacement of
Replacement of
Replacement of
Replacement of
Replacement of
Replacement of
Replacement of
Replacement of
Replacement of
Replacement of
Replacement of
Replacement of
Replacement of
Replacement of
Replacement of
Replacement of
Replacement of
Power Supply (5A1) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Audio Amplifier CCA (5A2) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Transistor Q1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Connector J9 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Connectors J2-J6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Electrical Binding Posts E1A, E2A, E1B, and E2B . . . . . . . . . . . . . . . . . . .
Resistor R1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Remote Control Transformer CCA . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Connectors P2 and P3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Wiring on Audio Amplifier Chassis Connectors . . . . . . . . . . . . . . . . . . .
Audio Amplifier Chassis O-ring Gasket . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Surge Arrestors or Diodes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Audio Amplifier Case . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Circuit Breaker CB1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lamp Holder DS1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Relay K1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Diode CR1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Zener Diode VR1/VR2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Side Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Para
4-14
4-15
4-16
4-17
4-18
4-19
4-20
4-21
4-22
4-23
4-24
4-25
4-26
4-27
4-28
4-29
4-30
4-31
4-32
4-33
4-34
4-35
4-36
Diode CR6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-37
Terminal Block TB2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-38
Power Control Chassis O-ring Gasket . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-39
Bottom Cover . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-40
Terminal Block TB1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-41
SNAP Line Driver CCA . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-42
Wiring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-43
Power Supply Chassis . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-44
P1 Connector . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-45
J10 Connector . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-46
J11 Connector . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
4-47
Page
4-97
4-97
4-98
4-99
4-100
4-101
4-104
4-106
4-107
4-109
4-111
4-112
4-113
4-115
4-117
4-121
4-122
4-125
4-127
4-128
4-129
4-131
4-132
4-135
4-136
4-137
4-141
4-142
4-144
4-145
4-150
4-152
4-153
4-154
4-14. GENERAL.
This section includes the operational check and the repair procedures. The operational check is used to verify
the operation of a repaired mounting adapter. lt is also used to verify the symptom of a faulty mounting adapter.
It will identify the troubleshooting chart to be used. When a bad module is identified, replace it using the
procedure in this section.
4-15. OPERATIONAL CHECK.
Perform the operational check found in paragraph 4-9 to verify proper operation of the mounting adapter.
4-97
